New panels
The new metal system go on over new underlayment.
Metal Roofing
Metal Roof Replacement Pequannock, NJ
A Pequannock roofer can tear off an old metal roof, re-cover it with new metal or replace a shingle roof with metal, and help you decide between a tear-off, a re-cover or new panels in just the bad sections. Dial (862) 458-0110 to talk with a local roofer about replacing the roof.
The line between repair and replacement on metal is whether the panels are still sound. When panels are perforated by rust, the finish is gone and every screw hole has been enlarged by years of movement, repairs stop keeping up. Older galvanized roofs with little coating left are the common candidates.
Not every metal roof replacement starts with a tear-off. Stripping the old metal exposes the framing, which matters because fasteners in rotten wood will not hold. Retrofit re-covers add a new metal roof over the old one, attached through to the structure.
A big share of metal replacement work is switching a worn shingle roof to metal. Depending on code and deck condition, the old shingles are either removed or covered. Have the age, roof type and leak history ready when you call.
If the problem goes deeper than it first looked, a Pequannock roofer may also recommend metal roof installation or metal roof repair.
Looking for Pequannock metal roof replacement? Call (862) 458-0110 to reach a nearby roofing contractor.
Call nowThe process
The metal roof replacement process
Here is how a metal replacement usually goes.
Check the framing
A full look at the panels, framing and attic shows whether the roof can be re-covered or must come off. It also tells whether the framing needs work first.
Plan the new roof
Tear-off, re-cover or metal over shingles is chosen, along with the new panel system, gauge and finish. Switching to standing seam usually means adding solid decking.
Strip the panels
The crew unscrews and lifts off the old metal, stacking it for recycling. Sections are opened only when they can be dried in that day.
Restore the deck
Rotten purlins are replaced, loose ones refastened and soft decking cut out and renewed. New screws in rotten wood would fail within a few seasons.
Put on the new roof
The roof is dried in, trimmed and paneled, with new boots and flashing at every penetration. Snow guards and ventilation are added where needed.
What is included
What metal roof replacement includes
Framing repair
Damaged structure is repaired so fasteners hold.
Re-cover option
A retrofit re-cover avoids a tear-off on larger buildings.
Tear-off
Failed panels and trim come off so the structure can be inspected.
New trim
All new eave, rake, ridge and wall trim in the same finish as the panels.
Related service
Metal Roof Panel Replacement Pequannock, NJ
When only a few panels are rusted through or torn, metal roof panel replacement can keep the rest of the roof in service. On exposed fastener roofs, the roofer removes the screws on the damaged panel and the overlapping edges of its neighbors, slides it out and sets a new one in sealant. Standing seam panel swaps are possible but slower, since the seams on both sides have to be opened.
Many Pequannock roofs need only a few panels replaced after a storm or a falling limb. The new panels may look brighter until they weather. Once a large share of panels need work, replacement becomes the better plan.
Related service
Metal Roof Over Shingles Pequannock, NJ
A metal roof over shingles skips the tear-off and installs panels over the current shingle layer. Where code permits, the roofer adds underlayment or furring strips over the shingles and fastens the metal through to the deck.
The tradeoff is that nobody sees the deck. Before going over shingles on a Pequannock home, the deck is checked from inside and any soft areas are found. Two existing layers or any doubts about the deck mean a tear-off.
Local help
Metal Roof Replacement Near Me
Around Pequannock, metal reroofs range from rusted farm buildings to houses getting their first standing seam roof. From Pequannock out to neighboring towns such as Pompton Plains, Lincoln Park, Towaco and Riverdale, older metal roofs tend to need full replacement once the coating is gone, and newer houses are adding metal as their shingle roofs wear out, which is why the condition of the purlins and deck drives the plan.
Need metal roof replacement around Pequannock? Call (862) 458-0110 for a Pequannock roofer who serves the towns around it too.
What the local climate does to a roof
Cold winters bring snow, ice and a long stretch of freezing nights. Heat escaping from the attic melts snow on the upper roof, and the water refreezes at the colder eaves, which is how ice dams form and back water up under the shingles. Coastal storms and heavy spring rain drive water sideways into flashing, valleys and old chimneys. Most homeowners in Pequannock, NJ have the roof checked in the fall and again after the snow melts.
Why call
Why act early
Smaller repairs
A roof problem fixed early rarely spreads to the decking, the insulation or the ceilings.
Local knowledge
Local roofers see the same roofs and storm damage across Pequannock and nearby towns.
Clear next steps
Ask the roofer about the cause, the options and the estimate before work starts.
Common questions about metal roof replacement
When does a metal roof need replacing instead of repair?
The tipping point comes when rust or wear is spread across the roof, not just in a few spots. If panels are perforated, the coating is gone and the fasteners no longer hold, patches will not keep up. Call (862) 458-0110 to have a roofer check the roof and the structure.
Is it a good idea to put metal over shingles?
Where code permits, metal can go over a single layer of shingles. It saves tear-off and disposal, but it hides the deck, so the attic should be checked for rot and soft spots first. If the deck is questionable or there are two layers already, a tear-off is the better route.
Can a new metal roof go over the old metal roof?
In a retrofit, new panels go over the old roof on spacers or purlins. It avoids tear-off and keeps the building closed during work, which is why it is common on shops, barns and commercial buildings. The framing must be sound enough to support both layers.
Is old metal roofing recycled?
Removed metal panels are generally recycled. Unlike shingles, which usually go to a landfill, metal is sorted and sent for recycling. Your roofer can explain how the old metal will be hauled away.
Can I replace just one damaged metal panel?
Replacing one panel is a routine job on most ribbed and corrugated roofs. The screws and laps are freed, the bad panel slides out and a new panel of the same profile is lapped in with sealant and new fasteners. New panels may look brighter than the old ones at first.
More questions? Call (862) 458-0110
Related services
Metal Roof Installation
New metal roofs in standing seam, exposed fastener, metal shingle and stone coated steel, so the roof handles heat, wind and thermal movement.
Learn moreMetal Roof Repair
Metal roof repairs that stop leaks at the screws, laps and flashing, without replacing panels that are still sound.
Learn moreRoof Replacement
Replacing an aging roof with new underlayment, flashing, vents and roofing, built to current code from the decking out.
Learn moreStanding Seam Metal Roof
Long-lasting standing seam roofs, from snap-lock to mechanically seamed panels, with matching trim, closures and snow guards.
Learn more
Looking for something else?
See all roofing servicesTalk to a Pequannock roofer about metal roof replacement
Call (862) 458-0110 for a local roofer in Pequannock and nearby towns.